rtb pelet boiler riga
Gas rtb pelet boiler riga furnaces and cooking formal operation of the boiler furnace 1, and its object is to clear the body of the boiler impurities, grease and rust. The inspection of boiler installed and cold test run, each member confirms perfect safety conditions have hot start operation to start cooking stove. 2, boiling out dosage (see table below) Unit: kg / t rust grease Drug Name Notes thicker thin rust grease sodium hydroxide (NaOH) 2 ~ 33 ~ 4 trisodium phosphate (Na3PO412H2O) 2 ~ 33 ~ 4 when no trisodium phosphate, sodium carbonate can be used (of Na2CO3) in place of an amount of 3 to 6 kg / t water. 3, when dosing, the low water level in the boiler water should, boiler water should be the highest level, the drug was added on the stove interfaces (e.g., valve opening) when the cooking stove. 4, the end of the cook should the boiler furnace pressure was kept at about 75% of the working pressure, time is generally 2 to 3 days. 5, during the cooking stove, boiler water periodically take laboratory analysis, alkalinity boiler water of not less than 45 meq / L, should be added or dosing. 6, oven cooking is completed, the drum and the current tank should be cleaned precipitate, rinsing the boiler and in contact with the agent through a valve, to check whether or clogging sewage. 7, after cooling boiler, furnace water will be fully released. Open manholes, hand holes, repeatedly washed with water until the furnace no rust, grease qualified. (Ix) a test run, the test run should be with a load, for 4 to 24 hours (set maximum, minimum operating pressure). 2, observe the safety valve and various safety accessories, protective devices and other operations are sensitive and reliable. 3, after the commissioning of qualified, supervisory inspection agency should be acceptance.
180 ton CFB coal fired rtb pelet boiler riga advantages:
1) It has higher burning efficiency and higher heat efficiency.
2) It can realize getting rid of sulfur inside the furnace by adding CaCO3 and the efficiency can catch up to 90% and above and this is done at low temperature which can prevent from producing NOx and is good for protecting environment.
China Dunhuang International Hotel relevant responsible person said, party fast or aftermarket both in pre-sales, remained consistent patient service, we have solved many difficult problems, with fast rtb pelet boiler riga, we are assured. --customer feedback
A small category 1 gas rtb pelet boiler riga, soft drinks dual small boilers: Rated evaporation does not exceed 0.5 t / h, rated steam pressure not more than 0.04 MPa; 2, a small hot water boiler: rated does not exceed 0.1 MPa water pressure, water pressurized hot water boiler; 3, small steam boiler: water no more than 50 liters capacity, rated steam pressure does not exceed 0.7MPa; 4, small pressure boiler aluminum: aluminum bulk material selection, not the rated steam pressure outlet than 0.04 MPa and not more than 0.2 rated evaporation t / h.