low pressure waste oil cooking fired steam boiler
Multiple protection devices take you through the oil low pressure waste cooking fired steam boiler oil steam boiler water level protection, boiler water level gauge plate supporting one to two, should always be compared with each other, findings indicate inconsistency shall be corrected immediately. Class water level should be flushed, to determine their true level. While the water level comes electrode rod can accurately capture level signal to an alarm or a pump control. Steam pressure protection, the pressure controller: selection of high sensitivity of the pressure controller, the pressure is high, or low levels of signal to the electrical switches, automatic control chain protection or other control lines. Using pressure controllers and electrical contacts, the vapor pressure can overpressure alarm; single adjustable pressure controller or dual fire burning fire the actual operating pressure. Safety valve: safety valve is the last line of defense to protect the boiler, the boiler pressure exceeds the limit, according to the set pressure relief valve design with the school, the exhaust steam pressure relief, to ensure the normal operation of the boiler. Flame protection, having imported burner flame protection means, combustion function is to detect, when the ignition failure or extinguish combustion middle, immediately off the burner into the oil (gas) solenoid valve, the blower continues to operate at this time, the furnace was purged of residual internal combustible gas, after 20 to 30 seconds purge, and various auxiliary blowers automatically cut off power, the boiler operation stops. Self-locking power protection case, the boiler shutdown immediately burst self-locking power interruption, if the current power is restored, the boiler will not start at any time, you must reset release self-locking, to re-start the ignition.
The main factors affecting small type gas low pressure waste cooking fired steam boiler steam boiler thermal stability of gas ignition is not difficult to establish a stable small fire signal, the root cause is a small fire detectors can not detect normal to the fire. Gas-fired steam boiler burner underlying mode, two-pass configuration, the fuel combustion, the boiler operation is stable and take up less space, while the spoiler is inserted smoke tube, smoke slow speed, increase heat transfer, a high thermal efficiency, reducing user fees biomass boilers categories: biomass boilers horizontal, vertical biomass boilers. Biomass gas thermal oil heaters, biomass steam boiler, biomass hot water boiler, biomass oil furnace. Function gas boiler the ignition system that ignites the mixture of air and fuel, its main components are: the ignition transformer, the ignition electrode, a high voltage electrical cable fire. A more secure electronic ignition system called ignition pulse, is widely used Zhuoyi energy saving gas boiler manufacturers. Which facilitate saving, can simply press a finger, and safe, does not occur due to unexpected accidents occur flame, once the stall state occurs, the control system can close the solenoid valve, off the gas passage. Small fire detectors use the ionization fire detection, and requires effective contact area of the flame, the flame stability and proper size, the gas pressure must be controlled within a very strict range. If the ignition gas pressure is too high, too long a small fire flame is moved beyond the detection range of the small fire detection probe, the system will not be mistaken for a small fire; if the gas pressure is too small, the gas will be firing too small and the boiler the blast very, very easy to blow out the flame, the ignition is not possible. Also, fire gases found a small pressure regulator valve regulating performance is not good, fine adjustment can not be achieved. Stability is also related to a small fire and the ratio of the size of the boiler furnace pressure boiler feed valve. The damper is too large or too small can affect the stability of the flame is ignited and the flame, furnace pressure will lead to extinguish the flame. In order to ensure the accuracy of fire detection, fire detection, we can adjust the small depth of insertion of the probe, the position of the fire detection probe in the correct position, in order to more effectively detect small fires flame.
Our company in the choice of boiler products, attaches great importance to the quality of emissions and low pressure waste cooking fired steam boilers, boiler low emissions of pollutants party provides fast, good steam quality is superior boiler products. --customer feedback
8 ton condensing fuel gas-fired boilers in Russia
ZG boiler re-export project—a full set of 8 tons of condensing fuel gas-fired boilers was exported to St. Petersburg, Russia. As the economic power of Russia, St. Petersburg takes industry as the main development point, and is a highly developed international city of science, technology and industry. Therefore, the selection requirements for production equipment are very high. The ZG boiler oil and gas boilers feature the internationally popular classic “all-wet-back three-return” design structure, FRG flue gas recirculation, condensation prevention and control, and other special technical advantages to enable Russian customers to successfully sign a complete set of 8 tons of WNS with ZG boiler within a week. Type saturated steam boiler contract, the fuel is natural gas and diesel. In addition, based on Europe's strict boiler emission standards, ZG boiler has configured pure Italian imported burners for customers.