3 tph oil boiler
How fuel (gas) 3 tph boiler stack height standards should be implemented as specified?According to requirements "Boiler Air Pollutants Emission Standard" -GB13271-2014 existing files countries, oil, gas boiler chimney of not less than 8 meters, the height of the boiler chimney by specific approval of environmental impact assessment documents OK. When there is a building within a radius of 200m from the new boiler room around the chimney, the chimney should be higher than the tallest building in more than 3m.
How to improve the thermal efficiency of 3 tph boiler?
Boiler design efficiency in the engineer design phase, and in general, the actual operation and the initial design thermal efficiency are similar. For example, oil and gas furnace efficiency is greater than 92%, and circulating fluidized bed boiler efficiency is usually higher than 88%. However, boiler efficiency is not fixed. If your equipment is operating at less than design efficiency, then measures can be taken to improve boiler thermal efficiency.
Henan gas 3 tph boilers and waste heat boilers have different it as long as the difference between Henan gas boilers and waste heat boilers are: 1 boiler heat source Henan gas is to use the medium of combustion (coal oil gas, etc...) Is obtained, and the heat source waste heat boiler is the use of industrial combustion waste heat waste heat. 2. Structure of Henan gas boiler and a bit more complex ancillary equipment, and waste heat boiler structure is relatively simple, the kind of industrial boilers and more, waste heat boiler is now more straight-through waste heat boiler. 3. parameters Henan gas boiler (pressure, level, temperature) and the like can be easily controlled because the combustion control, the operating parameters of the waste heat boiler is difficult to control, the operation of the heat source is a waste heat boiler with a combustion cycle in an industrial furnace varies . 4. Henan gas-fired boiler is mainly used for gas and steam turbine power generation and other support, waste heat boilers are generally equipment industrial furnace, that there are energy saving and environmental protection.
Jilin Province is located in northeast China, colder winter. Jilin Province is the autumn and winter air pollution problems are most acute period is the peak period of fog and haze. To reduce the frequency of occurrence of fog and haze, to reduce emissions of air pollution, according to "implement the central Jilin Province Environmental Protection Inspector feedback reform program", Jilin cities to carry out the 2018 autumn and winter special law enforcement inspection of non-electric coal-fired 3 tph boilers. Specific implementation of the program as follows.
2018 autumn and winter non-electric coal-fired boiler special law enforcement inspection action plan
First, the objectives
Through the "2018 autumn and winter special law enforcement inspection of non-electric boiler coal" action to further increase the intensity of emissions of air pollutants such as excessive penalties for violations combat, urge local governments and environmental protection departments to effectively implement the "Jilin province to implement the central environmental protection inspector feedback reform program, "Forced enterprises to speed up 10 tons of steam coal-fired boilers small and out of more than 20 tons of steam and non-electric coal-fired boiler pollution control facilities upgrade progress to ensure stable discharge standards.
Second, the scope of the inspection
Cities (prefectures) and Changbai Mountain Administrative Committee, Meihekou, Gongzhuling City, Hunchun.
Third, check the time
2018 Nian September 1 to November 30.
Fourth, inspection methods and content
Cities (prefectures) and counties under the jurisdiction of Changbai Mountain Administrative Committee to set up inspection teams to units in the area to take a cross peer review mode, Meihekou, Gongzhuling City, Hunchun to self-oriented.
The principle of mutual cross-check on the environmental violations found, the city's environmental protection departments at all levels in accordance with "should check to make investigation, should make a fine penalty, should be moved to make-shift" of errant given time out of the boiler, not dust removal facilities renovation no construction of desulphurization facilities are not required to install, networking, using automatic monitoring equipment, excessive discharge of pollutants and other acts take full advantage of "environmental law" and supporting measures to implement daily basis penalties, limited production shutdown, sequestration, administrative detention measures to deal with.
Focus on examination of the following:
(A) the progress of 10 tons of steam coal-fired boilers little out of work. According to "implement the central Jilin Province Environmental Protection Inspector feedback reform program," according to the time limit set by local governments, the progress of the phase-out of coal-fired boiler 10 tons of steam since 2014, the province's illegal 1570 newly registered units to be checked.
(B) more than 20 tons of steam coal-fired boiler non-electric dust removal, desulfurization facilities upgrade progress, automatic monitoring equipment installation, networking, usage. By ShengTing 6, July scheduling, the current to complete the rectification stage 717, stage 108 does not start the rectification, the rectification is 277, automatic monitoring equipment table 140 is not installed, the slow progress of the rectification. To complete the transformation around the boiler on-site verification, focusing on inspection facilities dust removal, desulfurization facilities upgrading and installation of automatic monitoring equipment, networking, usage. Percentage being modified, check the current progress of the major transformation of the situation, progress of the project, the time frame for completion, safeguard measures taken, it requires the use of boiler units issued commitments. For failure to start the transformation, to identify the main reason for not starting. If we do not transform the way in which the pin number to take all necessary construction and renovation tasks must be completed in accordance with the requirements of 30 September.
(C) boiler emissions standards. To install automatic monitoring equipment to monitor them than to confirm the validity of the data. For failure to require the installation of automatic monitoring equipment, shall be punished in accordance with relevant laws and regulations, at the same time supervisory monitoring, to determine whether to achieve a stable discharge standards.
Fall and winter heating season is the peak of Jilin Province, to ensure the normal heating units, we must also pay attention to boiler problems in the process of environmental protection. For the high-emission, high-polluting coal-fired boiler and other fuel boiler, to be banned or corrective action.