How much gas steam boiler
Hot water boiler in the school dormitory and classroom building are generally used for central heating, drinking water and bathing water aspects of teachers and students and so on. Shanxi Linxian County high school is an important educational school personnel training for the community. 2017, the school responded positively to national coal to gas and other environmental policies, but also to provide students with a more favorable living and learning environment, the school decided to phase out conventional coal-fired boilers, clean and environmentally friendly replacement for the gas boiler. After getting to know and choose the boiler industry, major companies, determined cooperation with professional production of clean fuel boiler fast boiler-by-side to provide a fast 4.2MW integrated condensing gas hot water boiler (WNS4.2-1.0 / 115 / 70-YQ).
Industrial boiler market share rise, to the current trend of energy-saving industry, industrial boilers are mainly used in metallurgy, chemicals, coke, cement, paper, shipbuilding and other industries, mainly through heating boiler, steam production unit each to provide the required or hot water. Different transformation and power industry, industrial boilers since often small cell capacity, installed at the rear end of expensive desulphurization and denitrification apparatus is very uneconomical, so the transformation of coal will be the main alternative route, the coal gas, biomass fuels, cleaning three coal technology route, clean coal will assume the main task. By the end of 2011, the total industrial boilers reach 58.5-60 million units, of which the boiler, the capacity accounted for more than 80% of coal-fired boilers, boiler capacity is less than the number of 35 tons / hour of 96% of the total, while 10 accounting tons / hour up to 80%. Meanwhile, the average thermal efficiency of industrial boilers only 60%, 20-25% lower than in other countries. The country's industrial kilns more than 160,000, concentrated in building materials, metallurgy, chemicals and ceramics and other industries, the annual coal consumption of 300 million tons. The average heating furnace thermal efficiency of only 40%, 10-30% lower than in other countries. A wide range of large industrial boilers in China, the average capacity of small and dominated by coal. Although China's coal-fired industrial boiler design productivity gap compared with foreign small, but the actual operating efficiency of only 65%, 10% -15% lower than the advanced level. Industrial boilers with maximum downstream chemical materials and chemical products manufacturing market size, non-ferrous metal smelting and rolling processing industry, petrochemical industry market size is large, in addition, the market size paper and shipbuilding industries is relatively small, moderate growth in the cement manufacturing industry . Overall, the future of Chinese boiler market demand is still the main metallurgy, chemical and petrochemical three coking industry, and paper, cement and other industries demand is relatively weak, shipbuilding recession has not slowed. Industrial boilers, especially coal-fired industrial boilers for energy saving is important for achieving the overall goal of energy conservation.
What is the reason for how much steam boiler explosion? Boiler itself is flawed: the pressure component aging, strength weakened, or leakage, corrosion, deformation, scaling and other defects can not be timely maintenance and eliminate hidden dangers, but let the disease run with the boiler and so on. Fuel gas boiler is not only fuel but also refers to the gas boiler. Previously no such dual-fuel boiler, burner because either fuel or gas, no dual fuel burners. With the rapid development of the world energy equipment, some European countries begin production and sales of fuel gas burner, dual fuel burner and boiler combination of organic birth of a new breed of boiler - fuel gas-fired boiler. Therefore, we must carry out regular inspection of boilers in accordance with national requirements. 3. poor management, furnace workers irresponsible or low levels, lead to misuse. Therefore, furnace workers must obtain a certificate as required. None of the above is the main reason for the actual boiler explosion. In actual operation, the most common situation is that the boiler add cold water and drying, which is very dangerous. Biomass boiler is a kind of boiler to biomass energy as a boiler fuel called biomass boilers, steam boilers into biomass, biomass hot water boiler, biomass stove, biomass thermal oil heaters, vertical raw biomass boilers, biomass boilers and other horizontal. This is also the operators need the most important thing vigilance. There may be debris blocking the pressure cooker vent, causing the pot to continue to increase pressure, excess pressure can not be discharged to reach the pot of strength, can withstand the pressure will naturally explode, of course, does not rule out the cause of pan itself. Substandard quality, tank leaks, inadequate exhaust usually cause an explosion. Therefore, before use, carefully check the vent is smooth, not to violate the specification and taboos, without any danger.
There are build on the control of emissions of nitrogen oxides boiler in order to achieve NOx emissions from combustion boilers of less than 30mg / m3, reached the world advanced level. Austrian far low nitrogen fuel gas boiler Staged Combustion Process of the invention into three regions in the furnace combustion techniques, primary combustion zone into the small portion of the fuel, the fuel required for the combustion air into the furnace in stages, the air volume of 80% left and right into the main combustion zone, the primary combustion zone of the upper (downstream of the flame) of the fuel injected into the secondary combustion and the formation of Carrying out a reducing atmosphere in the third zone into the combustion air required Further, complete burnout process. To create a discharge for the control of nitrogen oxides boiler fuel and air in order to achieve staged combustion gas boilers achieve emission limits is very basic configuration of environmental protection facilities, comprising an electrostatic precipitator or bag filter, gas boiler efficient desulfurization apparatus, a selective catalytic reduction (SCR) or selective non-catalytic reduction (SNCR) and the like denitration apparatus. All aspects of air pollution sources to install automatic monitoring facilities, how much steam boilers and networking with the environmental protection department, install a distributed control system (DCS system), real-time monitoring of gas boiler pollutant emissions. All-premixed combustion technology implementation of a number of Austrian far improved combustion technology after years of build have on the control of emissions of nitrogen oxides boiler fuel and air in order to achieve staged combustion. This technique can be gas boiler NOx emissions chain by 70% -60%. At present, to solve pollution problems of small and medium industrial gas boilers have four energy saving way. First, clean fuels covered by the remaining gas boilers, boiler premix combustion technology implementation of a number of improved combustion technology after years of Austrian far as natural gas boilers, biomass boilers and so on; Second, the rising water boiler technology.