bathroom steam boiler hyderabad
For the system, the system exhaust gas temperature lower than the conventional gas boiler, as shown herein, a larger amount of condensate, which requires purification test discussion. Test systems used direct touch touch flue gas condensing heat exchanger, the advantages of this method is that: the touch area greatly added flue gas two-phase flow of water, heat and mass transfer end instant, reaches the heat transfer enhancement effect.
Flue gas condensation in aqueous industrial boilers and industrial boiler flue gas condensing position of the condensation water and the condensed position 1, the bathroom steam boiler hyderabad flue gas dew point of industrial coagulation process means starts to condense water vapor in the flue gas the temperature, condenses into water vapor when the temperature is lower than the dew point temperature. Without considering the impact of the acid gas, flue gas dew point increases to increase, increasing the concentration of water vapor in the flue gas, increases as the excess air ratio is reduced. Formation of condensation water depends on the temperature distribution of the flow cross-section. For example, when the flue gas through the pipe, the core flow temperature maximum, minimum wall temperature. When the wall temperature is higher than the dew point, no condensate water, when the wall temperature below the dew point temperature of the core flow above the dew point. When the core flow temperature below the dew point, the air flow condensing section. Number of smoke generated condensed water is affected by many factors, such as size, fuel, exhaust gas temperature, the air ratio, the structure of the boiler heat transfer surfaces and the like. 2, boiler condensate condensed gas industry position in the boiler in order to improve the thermal efficiency of the boiler, efficient recovery of the latent heat of the flue gas steam gasification boiler with a condenser and is widely used in industrial heating systems, i.e., by installation absorb latent heat of water vapor in the flue gas. Saving device and a condenser. At design conditions, the flue gas temperature at the outlet of the boiler body above the water vapor dew point temperature, water vapor in the flue gas mainly in the condenser and economizer. Since the high-temperature steam in the boiler, the exhaust gas temperature before the flue gas enters the economizer is generally higher than the dew point, so a small amount of water vapor generated by the boiler condensate, hot water boilers and boiler due to low temperature, return water temperature lower than the annealing furnace smoke gas dew point temperature. Winter start or low load operation, leading to the exhaust gas temperature below the dew point temperature. Thus, prior to entering the economizer, some of the water vapor in the flue gas of the boiler tail heating surface condenses into water. The above analysis, generating the main part of the condensed gas are in industrial boiler economizer heating surface and the boiler, and thus boiler economizer outlet gas industry are usually set in a drain nozzle of the heating surface.
The use of central heating hot water boiler is the best choice for winter heating in northern China. Shanxi Province is located in Chang Darrow Heating Co., Ltd. mainly provides heating and post-service maintenance of heating equipment, heating clients involved in enterprises and institutions, office buildings, residential housing and a variety of commercial and other entertainment venues. With the wide blue sky covered Battle of the project, China's gradual increase in the proportion of heating for cleaning, heating, Ltd. Dalong Chang respond positively to the call of national policy, high pollution intensity wishing previously used, low thermal efficiency of coal-fired boiler to replace the traditional use hot water boiler clean fuel. After comparing many boiler manufacturers, choosing the optimal selection, determined and professional cooperation parties do fast boiler fuel boiler cleaning equipment. Providing a fast side 35 MW gas tube hot water boiler (SZS35-1.6-Y.Q) according to their actual needs.
35 tph ZZ series mid-temperature and mid-pressure coal-fired bathroom steam boiler hyderabad project for paper industry
Founded in September 2016, Rashid Paper Mills Ltd. is a subsidiary of Rashid Group. The company is mainly engaged in the production of paper products such as writing paper, printing paper and offset printing paper. At present, the company has two independent production lines. With a capacity of 200 tons of paper per day, the company exports high-quality paper to the overseas market. In order to ensure the heat source supply of its production lines, Rashid Paper Mills Ltd. introduced a set of ZOZEN ZZ series mid-temperature and mid-pressure boiler from China. With a design pressure of 3.82 MPa, the boiler can provide sufficient high-temperature steam.